Announcements

Job offersmore »



Tweeting Growers

Top 5 - yesterday

  • No news has been published yesterday.

Top 5 - last week

Top 5 - last month

Exchange ratesmore »




"Retractable cooling house perfect fit for high temperature horticulture"

Greenhouses and other controlled environment agriculture practices are often advertised as the solution to grow year round in any climate and in any location. Richard Vollebregt of Cravo however, believes that his retractable cooling houses are a better solution for growers in hot climate countries.



"A conventional greenhouse, whether it is glass or plastic, is a perfect fit for a climate with cold winters, such as in Canada, The Netherlands or Russia. In these climates the greenhouse can keep the crops warm during winter and provide a cool, protected environment during the mild summer. "However, when you go to any country between the equator and latitude 30, cooling is a much bigger problem than heating. Here conventional greenhouses typically struggle to produce good quality fruits at a low cost during the hot summers. In fact many naturally ventilated houses are empty during the hot summer conditions." 

"Therefore, any grower located between the equator and latitude 30 can achieve greater yields and higher quality using a retractable cooling house. This is because the roof covering is designed to block excessive heat before it enters the house, as where a ventilation system uses <2 kilowatt per hour of electricity per hectare per day and minimal water for cooling. The ability to retract hectares of cooling roofs in minutes when outdoor conditions are optimal allows growers to take advantage of full sunlight and lower humidity conditions. This is especially important for growers of berries and lettuce."

Over the last couple of years, Cravo has gained significant experience with the use of their retractable cooling houses in many locations throughout the world. "Retractable cooling houses were developed specifically for countries where conventional greenhouses and nethouses struggle to maintain optimal growing environments when outdoor temperatures are 35C-50C."

In these hot climates, many growers used pad and fan cooling but found the electricity and water usage prohibitive. Some growers then switched to lower cost nethouses but found that their harvest season was limited by the summer heat, the winter cold and rain. The retractable roof cooling house plus a layer of insect net combines the advantages of a nethouse with the climate optimisation of a retractable roof which eliminates the problems with conventional net house agriculture."


In this video, Richard Vollebregt of Cravo explains the difference between a conventional greenhouse and a retractable cooling greenhouse. He also highlights the system's potential to create better performing crops, with less inputs and a minimal ecological footprint as energy-guzzling pad and fan cooling are no longer required to grow in a hot climate.

To create the best practices and protocols for growing between the  equator and latitude 30, Cravo built a retractable cooling house in Culiacan Mexico. This house is used to grow a variety of greenhouse vegetables and serves as their demonstration and training center to showcase the potential of the system. The combination of the retractable cooling roof and insect net has already achieved yields of 40-50 kg/m2 of tomatoes and 15-17 kg/m2 of colored capsicums during the winter production season and potential still exists to increase it further. This year, tomatoes, peppers and cucumbers will be grown 52 weeks per year with crops having been transplanted August 15 and March 1.  

“Most research in the world has focused on growing crops in a fully controlled environment. Our own research however, has taught us that  exposing plants to the natural outdoors in the morning when outside temperatures are ideal and then protecting them using the cooling roof causes plants to develop a much higher tolerance to high temperatures and greater fluctuations in humidity midday. The retractable roof trains the plant to grow a stronger root system and smaller thicker leaves which helps it sustain itself to extreme temperatures."

Cravo is currently building projects with their retractable cooling greenhouses in countries such as Oman, Mexico, Nigeria, Chile and Australia.

For more information
Cravo Equipment Ltd
Richard Vollebregt
President
30 White Swan Road,
Brantford Ontario, Canada N3T 5L4
Phone: +(1) 519 759 8226 x 215
Mobile: +(1) 519 732 8054
Skype: richardvollebregt
richardv@cravo.com
www.cravo.com

Publication date: 4/6/2017
Author: Boy de Nijs
Copyright: www.hortidaily.com

 


 

Other news in this sector:

8/10/2017 US: Healthy Soils the focus of California State Board of Food and Agriculture
8/10/2017 Tech-savvy farmers a new hope for Japan's shrinking agriculture sector
4/26/2017 India: Large microirrigation project for Jain
4/26/2017 "Biochar boosts tropical but not temperate crop yields'
4/18/2017 Tale of misery that is Kenya’s addiction to tobacco economy
3/10/2017 Spend $6 million on a greenhouse project, and leave it vacant....
1/13/2017 Can robots destroy weeds better than a farmer driving a sprayer?
1/4/2017 Micro-sprinklers realize 32% water savings in open field strawberry crops
11/24/2016 Open field days at Rijk Zwaan Hellas
11/4/2016 US (CA): Open field tomatoes with half the nitrogen and a third less water
9/9/2016 Lettuce transplanting system saves labor, increasing yields
9/7/2016 Australia: 13.6% of agricultural land is in foreign hands
8/25/2016 UK: AHDB Horticulture provides vital Diamondback moth control
4/26/2016 Canada (ON): Vineland creating opportunities with okra
4/19/2016 Cooler Swedish climate makes sweeter strawberries
4/19/2016 Canada’s farmland values up but growth rate slowing
3/23/2016 US (TX): $10 million grant to address water challenges
3/22/2016 Australia: 'Fleece' keeping vegetable crops warm this winter
3/16/2016 US (CA): "State should do more to protect people against multiple pesticides"
2/8/2016 AU (QLD): Capsicum harvest brought forward with Maximinus