Announcements

Job offersmore »



Tweeting Growers

Top 5 - yesterday

  • No news has been published yesterday.

Top 5 - last week

Top 5 - last month

Exchange ratesmore »




Bacterial survival related to free chlorine concentration

US microbiologists published the first report on the strong correlation between the survival of aerobic bacteria and free chlorine (FC) concentration in the wash water of fresh-cut vegetables. The study focused on Romaine lettuce, Iceberg lettuce and cabbages.



Overall, the organic material load gradually increased over time as more and more produce was washed using the same water. The type of product and production volumes significantly affected organic material load increase rate. The survival of aerobic mesophilic bacteria in wash water, which is strictly related to FC concentration, was analysed during operations with all three vegetables regardless of the organic load in the wash water. In the majority of cases, bacteria survived when FC concentration was below 10 mg/L (=10 ppm) and especially when it was below 5 mg/L.

The increase in FC concentration led to a considerable drop of the frequency and population of bacteria detected. These results highlight the importance of maintaining a sufficient free chlorine concentration to prevent bacterial survival and cross contamination.

Determining a minimum effective free chlorine concentration to prevent pathogen survival and cross contamination is essential to develop food safety practices based on risk and scientific knowledge.

The correlation between FC dynamic concentrations and bacterial survival was studied during the commercial washing of chopped Romaine lettuce, shredded Iceberg lettuce and diced cabbage. The wash water was sampled every 30 minutes and assayed for organic loading, FC and total aerobic mesophilic bacteria after chlorine neutralisation.

Water turbidity, chemical oxygen demand and total dissolved solids increased considerably over time, even more so with cabbage. FC concentration fluctuated in response to chlorine dosage rates, product loading and water replenishment. Total bacterial survival showed a strong correlation with real-time FC concentration.

This study confirms that maintaining at least 10 mg/L of FC in the wash water strongly reduces the probability of bacterial survival and therefore the risk of cross-contamination.

Source: Yaguang Luo, Bin Zhou, Sam Van Haute, Xiangwu Nou, Boce Zhang, Zi Teng, Ellen R. Turner, Qin Wang, Patricia D. Millner, 'Association between bacterial survival and free chlorine concentration during commercial fresh-cut produce wash operation', 2018, Food Microbiology, Vol. 70, page 120-128.

Publication date: 11/24/2017

 


 

Other news in this sector:

1/18/2018 Only rarely unacceptably high levels of pesticide residues found in food
1/17/2018 Ghana: Veg exports resume after work to improve phytosanitary system
1/12/2018 E. coli outbreak in association with Romaine lettuce is over
1/10/2018 US: "FDA enforcement discretion enhances flexibility"
1/10/2018 "Starting a lab abroad"
1/9/2018 Spain: First phytosanitary control on Canary tomatoes passes without issues
1/5/2018 "Uncertainty is being created around Romaine lettuce"
1/4/2018 US (AR): Farm and produce safety workshops
1/3/2018 UK: Do you monitor for chlorate and perchlorate?
12/22/2017 Canadians advised to avoid romaine lettuce until further notice
12/15/2017 Do secondary standards make our food safer?
12/14/2017 Romaine lettuce linked to E. coli cases in Quebec and Canadian Maritimes
12/12/2017 US (IN): Purdue Extension provides Produce Safety Rule training
12/11/2017 USDA awards $24M in grants towards increasing food safety
12/7/2017 Global ID acquires Italian provider of organic and food safety certifications
11/30/2017 “Economic effects of the U.S. Food Safety Modernization Act”
11/29/2017 UK: "Number of toxic chemicals used on veg has increased 17 fold since 60's"
11/28/2017 Egypt: Authorities reject 354 containers due to non conformity
11/27/2017 UK: Phytosanitary certificates required for tomatoes from 2018
11/23/2017 EFSA promotes global approach to food safety on China visit